Dumper brake stuck
-
Topic author - Posts: 6
- Joined: Sun Dec 29, 2019 2:57 am
- Real name: Derry
- Has thanked: 1 time
- Flag:
Dumper brake stuck
Hi there..I have a stothert and Pitt sxd030 dumper recently bought it off a friend who left it parked up outside for 4 years. Brought it home got everything going and took it for its first spin after 1 minute or so dumper started to die out clutched and instantly stopped no freewheeling. Won’t move in 3rd and only in 2nd for a couple of seconds any ideas where to start with brakes.
-
- Posts: 4070
- Joined: Fri Jul 13, 2007 12:43 am
- Real name: essexpete
- Has thanked: 853 times
- Been thanked: 684 times
Re: Dumper brake stuck
Brakes perhaps? Has it got inboard oil immersed discs with cable actuated levers operating the handbrake? Sometimes the hand brake can not release properly and cause the brakes to bind. As the dumper is driven the brakes heat up and bind more.
Last edited by essexpete on Sun Feb 09, 2020 1:45 pm, edited 1 time in total.
-
Topic author - Posts: 6
- Joined: Sun Dec 29, 2019 2:57 am
- Real name: Derry
- Has thanked: 1 time
- Flag:
Re: Dumper brake stuck
No handbrake fitted at the moment and brake lines to rear axel disconnected only the pipe to front axel left on. Yes I think there inboard oil brakes can these stick or break internally
-
Topic author - Posts: 6
- Joined: Sun Dec 29, 2019 2:57 am
- Real name: Derry
- Has thanked: 1 time
- Flag:
Re: Dumper brake stuck
With machine jack up off the ground I can turn all wheels by hand...but when jacked up running and in gear I can stop each wheel by hand also with no real resistance :doh
-
- Posts: 4070
- Joined: Fri Jul 13, 2007 12:43 am
- Real name: essexpete
- Has thanked: 853 times
- Been thanked: 684 times
Re: Dumper brake stuck
So does the engine run normally up and down the rev range when the dumper is stationary?
With regard to stopping with out free wheel will the dumper coast on a slope? (be careful). If there are not any horrendous noises from the gear box/transfer box have you got odd size wheels/tyres?
With regard to stopping with out free wheel will the dumper coast on a slope? (be careful). If there are not any horrendous noises from the gear box/transfer box have you got odd size wheels/tyres?
-
Topic author - Posts: 6
- Joined: Sun Dec 29, 2019 2:57 am
- Real name: Derry
- Has thanked: 1 time
- Flag:
Re: Dumper brake stuck
think I’ve freed brakes out jacked up and left running in gear for a few hours all wheels seem to turn better now and will freewheel as well hopefully will be fine when loaded
-
- Posts: 475
- Joined: Thu May 17, 2018 6:08 am
- Real name: John
- Location: Coopernook. NSW. Australia
- Has thanked: 302 times
- Been thanked: 138 times
- Flag:
Re: Dumper brake stuck
Sounds promising, lets hope all is good to go. Make sure you get all your brakes hooked up and working.
Cheers Cobba
Who is online
Users browsing this forum: No registered users and 54 guests